After a certain period of use, agricultural machinery and tools will inevitably cause some failures. However, after failure, they cannot find the spare parts that need to be replaced. In this case, emergency measures must be taken to prevent the agricultural machinery from being damaged by secondary damage and to reduce the operation caused by the failure. Loss, the following describes several emergency methods for common failures of agricultural machinery. First, the principle of emergency repair of agricultural machinery failure should grasp the safety first, local conditions, local materials, simple and easy method. After the emergency measures are taken, they must first arrive at the repair shop to replace the replacement parts and materials, and use the regular repair methods to restore the original state of the art. Second, the agricultural machinery leakage: 1, once found in the use of agricultural machinery oil tank leakage, should immediately stop the operation (that is, shut down stall), check out the oil spill point, wipe the oil spill clean, with bubble gum and other temporary adhesive Block the oil spillage in time and temporarily block the oil leakage. After the farm machine is brought back to the repair shop, epoxy resin adhesive can be used to repair or replace the fuel tank directly. 2, the oil pipeline rupture must also immediately stop the operation, find the broken pipe, light oil pipeline oil spill first clean the pipeline, and then use a candle or soap in a layer of cracked coating, and then use the sealing tape wrapped in a broken pipe, and tied tight. 3, the oil leakage can also use the oil pipe cut off the broken pipe, the two ends of the good pipeline spliced ​​together, and then wrapped with sealing tape, and tied (this method is only used for longer pipelines). Second, the agricultural machinery into a mud pit, slippery driving: At this time can not force the throttle, so as not to damage the agricultural chassis or make the farm machinery wheel deeper and deeper, should first stop the operation, use tools to shovel the mud pit into a slope, covered with straw and other objects, Then start the farm machine, and then the forward gear will be used after the reverse gear to allow the agricultural machinery to drive out of the mud pit. Fourth, it is true that parts can not be driven out of Daejeon's agricultural machinery because of trailer damage. Because agricultural machinery is a heavy equipment, it is easy to cause secondary hazards such as rear-end collisions. Damaged agricultural machinery should not be used for towing, and the damaged agricultural machinery should be loaded into the repair plant by means of a trailer. When towing a trailer, the two cars must be kept at a distance from each other and run smoothly. Fufeng Sinuote Biotechnology Co.,Ltd. , https://www.sinuotebio.com
Third, agricultural machinery belt damage: can be connected at both ends of the belt with a wire and fixed, after temporary use, immediately go to the repair shop to replace the belt, or stop operating after the belt spare parts to be installed after use.